Electra OU7-24 RC Manual de servicio Pagina 145
- Pagina / 168
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
8
RESTART AFTER A LONG TIME
1. Check before operation
• Check that air outlets of the outdoor and indoor are not blocked.
• Check that the ground wiring is not broken off and is connected well.
2. Restore the air filter and the front panel
The air filter and the front panel must be fixed to the original position after having been cleaned.
3. Connect the main power switch
To protect the air conditioner, power should be provided 12 hours before operation. Then the
OPERATION lamp on the control box of the indoor unit will flash once a second .
PHENOMENA NOT CONCERNING MALFUNCTIONS
1. No operation
• The air conditioner does not work immediately after button is pushed.
For each Mode including Power OFF and SB, a Min time delay of 3 min before Comp. restarting,
excluding Deicing Mode.
2. A white mist of chilled air is generated from the indoor unit.
• Cooling in a room with a high relative humidity (in a place with much oil mist or dusts),
• The room temperature will be uneven if there is much filth inside the indoor unit. In this case, cleaning
is necessary. This work requires qualified person.
• If the air conditioner heats right after defrosting, the water will be sent out in the form of steam.
3. Noise
A kind of continuous low sound of hiss could be heard while the air conditioner is on operation. This is
caused by Freon flowing between the indoor and outdoor units causes this.
• A kind of hiss could be heard during the time of defrosting or right after stop. This is caused by Freon
changing its flow volume or not flowing any more.
• A kind of continuous low sound of rustle could be heard while the air conditioner is on
COOLING(including AUTO)or DRYING. This is caused by the drain pump which is running .
• A kind of squeak will be heard while the air conditioner is on or off operation. This is caused by the
inflation or deflation of the plastics of the unit due to the temperature fluctuation.
4. Dusts are blown out of the indoor unit
This occurs only in the case of the first use after a longtime rest.
5. Bad odor is coming out from the indoor unit
This is because the indoor unit gives off the smell impregnated from the wall, furniture, or smoking.
6. Turning to FAN ONLY while COOLING
• To prevent the heat exchanger from frosting, turn to FAN ONLY mode automatically and the
COOLING mode will be restored before long.
• When the room temperature reaches the set one, the compressor will stop to turn to FAN ONLY. In
the HEATING mode, the process is reversed.
SZ000286/En 06/22/2004, 4:44 PM9
CONTENT
- KN Cassette R410A Series 1
- LIST OF EFFECTIVE PAGES 2
- Table of Contents 3
- 1. INTRODUCTION 4
- 1.6 Outdoor Unit 5
- 1.7 Tubing Connections 5
- 1.8 Accessories 5
- 1.9 Inbox Documentation 5
- 1.10 Matching Table 6
- 2. PRODUCT DATA SHEET 7
- 2.2 KN 24 / OU7-24T R410A 8
- 2.3 KN 30 / OU8-30 R410A 9
- 2.4 KN 30 / OU8-30T R410A 10
- 2.5 KN 36 / OU10-36 R410A 11
- OUTDOOR 11
- PRODUCT DATA SHEET 12
- 3. RATING CONDITIONS 14
- 4. OUTLINE DIMENSIONS 15
- 4.2 Outdoor Unit: OU7-24 16
- 4.3 Outdoor Unit: OU8-30 16
- OUTLINE DIMENSIONS 17
- 5. PERFORMANCE DATA 18
- 5.2.1 Heating 19
- 5.3.1 Cooling 20
- 5.3.2 Heating 21
- 5.4 KN30 / OU8-30 R410A 22
- 5.5.1 Heating 23
- 5.6 KN30 / OU8-30T R410A 24
- 5.7.1 Heating 25
- 5.8 Pressure Curves 26
- 5.8.2 Heating 27
- 5.9 Pressure Curves 28
- -10 -5 0 5 10 15 20 29
- 5.9 KN36 / OU10-36 R410A 30
- 5.10.1 Heating 31
- 5.11 Pressure Curves 32
- 5.12 KN36 / OU10-36T R410A 34
- 5.13.1 Heating 35
- 5.14 Pressure Curves 36
- 5.14.2 Heating: 37
- 5.15 KN45 / OU10-47T R410A 38
- 5.16.1 Heating 39
- 5.17 Pressure Curves 40
- 5.17.2 Heating 41
- 6. ELECTRICAL DATA 42
- ELECTRICAL DATA 43
- 7. WIRING DIAGRAMS 44
- WIRING DIAGRAMS 45
- 7.6 Outdoor Unit: OU10-36 46
- 7.7 Outdoor Unit: OU10-36T 47
- 7.8 Outdoor Unit: OU10-47T 47
- 8. ELECTRICAL CONNECTIONS 48
- 9. REFRIGERATION DIAGRAMS 49
- 9.1.2 KN 30 R410A 50
- REFRIGERATION DIAGRAMS 51
- 9.1.3 KN 36 R410A 51
- 9.1.4 KN 36T R410A 52
- 9.1.5 KN 45T R410A 53
- 9.2 Cooling Only Models 54
- 10. TUBING CONNECTIONS 55
- ¼” ⅜” ½” ⅝” ¾” 55
- 11. CONTROL SYSTEM 56
- CONTROL SYSTEM 57
- 11.2 Control Function 59
- 11.3 General Functions 60
- 11.3.5 Protections 61
- 11.3.6 Thermistors Operation 61
- 11.3.7 RV Fault 62
- 11.3.8 General Features 62
- 11.4 Cooling Mode 63
- 11.4.3 Sequence Diagrams 64
- (RT - SPT) [ 65
- 11.5 Heating Mode 66
- 50)2( tt ICTandSPTRT 68
- 11.6 Heating, RC or SH Group 69
- 11.7.1 Sequence Diagram 70
- 11.8 Heating, RH Group 71
- 11.10.2 Sequence Diagrams 74
- 11.11 Dry Mode 75
- 11.11.2 DRY, SH or RH group 77
- 11.12 Protection 78
- Time [Hr] 85
- 11.16 System Diagnostics 91
- 12. TROUBLESHOOTING 92
- TROUBLESHOOTING 93
- 13.5 Indoor Unit: KN 36 98
- 13.6 Indoor Unit: KN 45 99
- *Optional 102
- 14. OPTIONAL ACCESSORIES 130
- Service Manual - KN Series 132
- OPTIONAL ACCESSORIES 132
- Revision Y06-02 132
- APPENDIX A 136
- CONTENTS 137
- INSTALLATION 138
- NAMES AND FUNCTIONS 140
- OPERATION ATTENTION 141
- TEMPORARY OPERATIONS 142
- ADJUSTING AIR FLOW DIRECTION 142
- MAINTENANCE 143
- RESTART AFTER A LONG TIME 145
- TROUBLES AND CAUSES 146
- REPARATION 147
- PRECAUTION 149
- INSTALLATION INFORMATION 150
- ATTACHED FITTINGS 151
- INSTALLATION PLACE 152
- INDOOR UNIT INSTALLATION 153
- CAUTIONS 154
- OUTDOOR UNIT INSTALLATION 156
- INSTALL THE CONNECTING PIPE 157
- Flaring the nuts 158
- Use the market brass pipe 158
- Operate the stop valves 160
- CHECK THE LEAKAGE 160
- CONNECT THE DRAIN PIPE 161
- WIRING 163
- 3. ELECTRICAL CONNECTIONS 164
- Figure 36: Three Phase Units 165
- 3.2 Interconnecting cable 165
- Chart 38 167
- TEST OPERATION 168
Relacionado con productos y manuales para Acondicionadores de aire del sistema de división Electra OU7-24 RC
(92 paginas)
(14 paginas)
(2 paginas)© 2020, manymanuals.es. Todos los derechos reservados | 0.112 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales